Ultramid A3X3G5 耐化学品 轴承 连接器 原料 PA66

PA66 Ultramid A3X3G5 巴斯夫 BASF德国巴斯夫UltramidPA66加工特性
PA66 Ultramid A3X3G5 巴斯夫 BASF熔融与凝固特性: Ultramid受热时的软化特性，可用据DIN53445测量的剪切模量和阻尼值与温度之间的函数关系进行。软化仅在温度怡好低于熔点时才较为明显，该熔点对于Ultramid T，约为270℃;对于UltramidA，约为240℃，对于UteamidB，约为200℃，玻璃纤维会使软化点升高，在较小的温度范围内(低于融点的20℃至40℃)，熔体也会凝固，这取决于冷却速率和相关的Ultramid产品等级。同时，体积收缩率为3%至15%左右。体积的总收缩量参见图1中的PVT图表。
PA66 Ultramid A3X3G5 巴斯去 BASF
热性能:Ultramid 的比热焓较高(如图30所示，与温度的变化关系)，不仅需要大功率的融化加热设备，且凝固和冷却时间较长，凝固和冷却时间与壁厚或直径的平方成正比,
PA66 Ultramid A3X3G5 巴斯夫 BASF
熔体粘度:使用毛细管流变仪测量、或通过注塑测试形成的粘度图，据此对Ultramid的熔体流变性进行评估。在加工温度范围内，Ultramid 产品的熔体为10至1，000Pa-s，实际值很大程度上取决于温度与萝切读率，相对摩尔质量或相对溶液粘度(由名称的*位表示)越高，则络体粘度越高，目流动阻力趟大(图30)，对于矿物填充或玻璃纤维增混型Utramnid 产品，粘度会随着增强材料的掺入量成比例增大。熔体粘度可能随时间变化而变化。例如，当熔体物质过于潮湿、过热或受到高机械剪切应力作用时，粘度就会快速下降，氧化也可能导致粘度下降。所有这些因素都会对成品部件或半成品的机械性能和抗热老化性产生影响。
PA66 Ultramid A3X3G5 巴斯夫 BASF
熔体的热稳定性:正确加工的情况下，Ultamid焰体具有出色的热稳定性，在正常加工条件下，材料不会受到影响或改性，仅当停留时间较长时，聚合物能才会发生降解，欲了解建议的加工熔体温度。
Ultramid产品范围手册。若熔体不与氧气接触，就不会发生明显的色变，当与空气接触(例如:使用开放式注射喷嘴时，或生产时出现中断)，表面在短时间内就会出现变色。
PA66 Ultramid A3X3G5 巴斯夫 BASF
预处理，干燥:Ultramid产品为片状或杜状粒料，采用防潮包装，无需预处理即可进行加工。若贮存(如放在故开的容器中)不当，建议在除湿或真空干燥器中干燥受潮的粒料。除湿干燥器是*有效、#可靠的工具，Ultramid的*容许干保温度约为80C至110℃，应在不超过80℃的温和条件下对热敏感的浅色粒料进行干燥，以防其出现泛黄或变色，干燥时间取决于水分含量(通常为4到8小时)，注举的#允许水分含量是0.15%，挤出加工的水分含量限值为0.19%，水分含量过高会引起降解和析出，尤其是对阳燃级产品进行干燥时，使用除湿于燥器进行干燥试验的结果(持续进行回风于燥)
PA66 Ultramid A3X3G5 巴斯夫 BASF
废料的画加工和画利用wltamid加工过程中产生的边角熔渣废物、不合格件等可有限地(不超过大约10%)进行再利用、这些废料必须未受到污染或未在加工中损坏，Utamd边角料易受湖，肌使储存在干燥条件下，也建议在加工前进行干燥。水分可导致材料分子在加工过程中发生降解。将研磨材料添加到原料粒子中，可能导致进料和流动特性、脱模性和收缩特性的改变，尤其是改变机械性能。

Ultramid 1403-2 BK ND3007 Nylon 66
Ultramid 1403-2 NF3001 Nylon 66
Ultramid 1503-2 BK ND3007 Nylon 66
Ultramid 1503-2 NF2004 Nylon 66
Ultramid 1503-2F BK ND3007 Nylon 66
Ultramid 1C Nylon 66/6
Ultramid 66 H2 G/25-V0KB1 BK3324 Nylon 66
Ultramid 66 H2 G/25-V0KB1 NAT0046 Nylon 66
Ultramid 66 H2 G/35-V0KB NAT0046 Nylon 66
Ultramid 66 H2 G/35-V0KB1 BK3324 Nylon 66
Ultramid 8200 HS Nylon 6
Ultramid 8202 Nylon 6
Ultramid 8202 HS Nylon 6
Ultramid 8202 HS BK-102 Nylon 6
Ultramid 8202 L Nylon 6
Ultramid 8202C HS Nylon 6
Ultramid 8202C HS BK-102 Nylon 6
Ultramid 8231G HS Nylon 6
Ultramid 8231G HS BK-102 Nylon 6
Ultramid 8231G HS BK-106 Nylon 6
Ultramid 8232G HS FR Nylon 6
Ultramid 8232G HS FR BK-102 Nylon 6
Ultramid 8233G HS Nylon 6
Ultramid 8233G HS BK-102 Nylon 6
Ultramid 8233G HS BK-106 Nylon 6
Ultramid 8234G HS Nylon 6
Ultramid 8234G HS BK-102 Nylon 6
Ultramid 8235G HS BK-102 Nylon 6
Ultramid 8253 Nylon 6
Ultramid 8253 HS Nylon 6
Ultramid 8253 HS BK-102 Nylon 6
Ultramid 8254 HS BK-102 Nylon 6
Ultramid 8255 HS Nylon 6
Ultramid 8260 Nylon 6
Ultramid 8262G HS BK-125 Nylon 6
Ultramid 8267G HS BK-102 Nylon 6
Ultramid 8267G HS BK-106 Nylon 6
Ultramid 8270 HS Nylon 6
Ultramid 8270 HS BK-102 Nylon 6
Ultramid 8272G HS BK-102 Nylon 6
Ultramid 8281 HS GP Nylon 6
Ultramid 8333G HI Nylon 6
Ultramid 8333G HI HS BK-102 Nylon 6
Ultramid 8333G HI HS BK-106 Nylon 6
Ultramid 8350 HS Nylon 6
Ultramid 8350 HS BK-102 Nylon 6
Ultramid A27 E Nylon 66
Ultramid A27 E 01 Nylon 66
Ultramid A34 01 Nylon 66
Ultramid A3EG10 Nylon 66
Ultramid A3EG3 Nylon 66
Ultramid A3EG3 BK00564 Nylon 66
Ultramid A3EG5 Nylon 66
Ultramid A3EG6 Nylon 66
Ultramid A3EG6 BK00564 Nylon 66
Ultramid A3EG6 FC Nylon 66
Ultramid A3EG7 Nylon 66
Ultramid A3EG7 BK00564 Nylon 66
Ultramid A3EG7 BK23189 Nylon 66
Ultramid A3EG7 FC Nylon 66
Ultramid A3HG2 Nylon 66
Ultramid A3HG5 Nylon 66
Ultramid A3HG5 BK00564 Nylon 66
Ultramid A3HG6 HR BK23591 Nylon 66
Ultramid A3HG6 WIT Nylon 6T/66
Ultramid A3HG7 Nylon 66
Ultramid A3HG7 BK00564 Nylon 66
Ultramid A3K BK00464 Nylon 66
Ultramid A3K Q601 Nylon 66
Ultramid A3L BK7793 Nylon 66
Ultramid A3L HP Nylon 66
Ultramid A3L HP BK20465 Nylon 66
Ultramid A3L HP UV Nylon 66
Ultramid A3L HP UV BK23220 Nylon 66
Ultramid A3SK Nylon 66
Ultramid A3U40G5 Nylon 66
Ultramid A3UG5 Nylon 66
Ultramid A3W Nylon 66
Ultramid A3W BK00464 Nylon 66
Ultramid A3W Q601 Nylon 66
Ultramid A3W R01 SW805 Nylon 66
Ultramid A3W2G10 BK20560 Nylon 66
Ultramid A3W2G6 BK20560 Nylon 66
Ultramid A3WG10 Nylon 66
Ultramid A3WG10 BK00564 Nylon 66
Ultramid A3WG3 Nylon 66
Ultramid A3WG3 BK00564 Nylon 66
Ultramid A3WG5 Nylon 66
Ultramid A3WG5 BK00564 Nylon 66
Ultramid A3WG6 Nylon 66
Ultramid A3WG6 BK00564 Nylon 66
Ultramid A3WG6 HRX Nylon 66
Ultramid A3WG7 Nylon 66
Ultramid A3WG7 BK00564 Nylon 66
Ultramid A3WG7 BK23210 Nylon 66
Ultramid A3WG7 CR BK564 Nylon 66
Ultramid A3WG7 HP BK20560 Nylon 66
Ultramid A3WG7 HP R01 BK20560 Nylon 66
Ultramid A3WG8 BK20560 Nylon 66
Ultramid A3WGM33 BK20560 Nylon 66
Ultramid A3WGM53 BK20560 Nylon 66
Ultramid A3X2G10 Nylon 66
Ultramid A3X2G5 Nylon 66
Ultramid A3X2G5 BK23187 Nylon 66
Ultramid A3X2G7 Nylon 66
Ultramid A3X3G5 Nylon 66
Ultramid A3XG3 BK20562 Nylon 66
Ultramid A3XZG5 Nylon 66
Ultramid A3Z Nylon 66
Ultramid A3Z HP Nylon 66
Ultramid A3Z HP BK20465 Nylon 66
Ultramid A3Z HP UN Nylon 66
Ultramid A3Z HP UV Nylon 66
Ultramid A3Z HP UV BK23220 Nylon 66
Ultramid A3Z3 Nylon 66
Ultramid A3ZG3 HP BK20465 Nylon 66
Ultramid A3ZG6 Nylon 66
Ultramid A3ZG7 HP BK20465 Nylon 66
Ultramid A3ZM2 BK30564 Nylon 66
Ultramid A4H Nylon 66
Ultramid Aqua UV BK20592 Nylon 66
Ultramid B24 N 03 Nylon 6
Ultramid B24 NE 01 Nylon 6
Ultramid B24 NSD 05 Nylon 6
Ultramid B27 03 Nylon 6
Ultramid B27 E Nylon 6
Ultramid B27 E 01 Nylon 6
Ultramid B27 SD 02 Nylon 6
Ultramid B27 SD 05 Nylon 6
Ultramid B29 HM 01 Nylon 6
Ultramid B32 Nylon 6
Ultramid B32 01 Nylon 6
Ultramid B33 01 Nylon 6
Ultramid B33 L Nylon 6
Ultramid B33 L 01 Nylon 6
Ultramid B33LN 01 Nylon 6
Ultramid B35EG3 Nylon 6
Ultramid B35G3 BK00564 Nylon 6
Ultramid B35G3 SI BK23216 Nylon 6
Ultramid B36 Nylon 6
Ultramid B36 01 Nylon 6
Ultramid B36 LN Nylon 6
Ultramid B36 LN 01 Nylon 6
Ultramid B3EG10 Nylon 6
Ultramid B3EG2 Nylon 6
Ultramid B3EG3 Nylon 6
Ultramid B3EG3 BK00564 Nylon 6
Ultramid B3EG4 Nylon 6
Ultramid B3EG5 Nylon 6
Ultramid B3EG6 Nylon 6
Ultramid B3EG6 BK00564 Nylon 6
Ultramid B3EG7 Nylon 6
Ultramid B3EG7 BK00564 Nylon 6
Ultramid B3G10 SI Nylon 6
Ultramid B3G8 Nylon 6
Ultramid B3G8 BK00564 Nylon 6
Ultramid B3GK24 Nylon 6
Ultramid B3GK24 BK00564 Nylon 6
Ultramid B3GM35 BK30564 Nylon 6
Ultramid B3GM35 BK60564 Nylon 6
Ultramid B3GM35 BKQ642 23220 Nylon 6
Ultramid B3GM35 BKQ649 23220 Nylon 6
Ultramid B3GM35 Ebony23227 Nylon 6
Ultramid B3GM35 Q611 Nylon 6
Ultramid B3GM35 Q643 Nylon 6
Ultramid B3K Nylon 6
Ultramid B3K BK00464 Nylon 6
Ultramid B3L Nylon 6
Ultramid B3L BK00464 Nylon 6
Ultramid B3M6 Nylon 6
Ultramid B3M6 BK30564 Nylon 6
Ultramid B3M6 BK60564 Nylon 6
Ultramid B3S Nylon 6
Ultramid B3S BK00464 Nylon 6
Ultramid B3S HP Nylon 6
Ultramid B3S Q661 Nylon 6
Ultramid B3U Q721 Nylon 6
Ultramid B3UG4 Nylon 6
Ultramid B3UGM210 Nylon 6
Ultramid B3UM4 Nylon 6
Ultramid B3WG10 BK00564 Nylon 6
Ultramid B3WG10 BK564 Nylon 6
Ultramid B3WG3 Nylon 6
Ultramid B3WG5 Nylon 6
Ultramid B3WG5 BK00564 Nylon 6
Ultramid B3WG6 Nylon 6
Ultramid B3WG6 BK00564 Nylon 6
Ultramid B3WG6 BK00564 BGVW Nylon 6
Ultramid B3WG6 CR BK23210 Nylon 6
Ultramid B3WG6 GIT BK807 Nylon 6
Ultramid B3WG6 GP Nylon 6
Ultramid B3WG6 GPX BK23238 Nylon 6
Ultramid B3WG7 Nylon 6
Ultramid B3WG7 BK00564 Nylon 6
Ultramid B3WG8 BK 00564 Nylon 6
Ultramid B3WGM24 BK30564 Nylon 6
Ultramid B3WGM24 HP Nylon 6
Ultramid B3WGM24 HPX BK23210 Nylon 6
Ultramid B3WGM24 sw23228 Nylon 6
Ultramid B3WM8 (8260 HS) BK-102 Nylon 6
Ultramid B3Z Nylon 6
Ultramid B3Z BK30464 Nylon 6
Ultramid B3ZG3 Nylon 6
Ultramid B3ZG3 BK30564 Nylon 6
Ultramid B3ZG4 Nylon 6
Ultramid B3ZG6 Nylon 6
Ultramid B3ZG6 BK30564 Nylon 6
Ultramid B3ZG7 OSI BK23273 Nylon 6
Ultramid B3ZG8 BK20560 Nylon 6
Ultramid B40 Nylon 6
Ultramid B40 01 Nylon 6
Ultramid B40 L Nylon 6
Ultramid B40 LN Nylon 6
Ultramid B40LN 01 Nylon 6
Ultramid B50L 01 Nylon 6
Ultramid BG40GM45 HS BK-130 Nylon 6
Ultramid BG50XFI Nylon 6
Ultramid BU50I Nylon 6
Ultramid BU50I BK-106 Nylon 6
Ultramid C31 01 Nylon 66/6
Ultramid C33 Nylon 66/6
Ultramid C33 01 Nylon 66/6
Ultramid C33 L Nylon 66/6
Ultramid C33 LN Nylon 66/6
Ultramid C33L 01 Nylon 66/6
Ultramid C33LN 01 Nylon 66/6
Ultramid C3U Nylon 66/6
Ultramid C3U BK23079 Nylon 66/6
Ultramid C40 L 01 Nylon 66/6
Ultramid C40LX 01 Nylon 66/6
Ultramid D3EG10 FC Aqua Nylon, Unspecified
Ultramid Endure D3G10 BK20560 Nylon 66
Ultramid Endure D3G7 BK20560 Nylon 66
Ultramid Endure D5G3 BM BK20560 Nylon 66
Ultramid HFX 32 Nylon 6
Ultramid HFX 33 Nylon 6
Ultramid HFX 35 Nylon 6
Ultramid HFX 37 Nylon 6
Ultramid HMG13 HS BK-102 Nylon 6
Ultramid HMG14 HS BK-102 Nylon 66
Ultramid HMG14 HS BK7795 Nylon 66
Ultramid HPN 9233G HS BK-102 Nylon 6
Ultramid HPN 9350 HS Nylon 6
Ultramid HPN 9362 Nylon 6
Ultramid N-265 NF3001 Nylon 66
Ultramid N-276 BK ND3007 Nylon 66
Ultramid N-276 NF3001 Nylon 66
Ultramid N-333 NF3001 Nylon 66
Ultramid S3K Balance Nylon 610
Ultramid Seal-Fit Nylon 66/6
Ultramid SEG7 Nylon 6
Ultramid SEG8 BK-126 Nylon 6
Ultramid SEG8 GY7716B Nylon 6
Ultramid SEGM35 H1 BK-126 Nylon 6
Ultramid Structure A3WG10 LF BK00564 Nylon 66
Ultramid Structure A3WG12 LF BK00564 Nylon 66
Ultramid Structure A3WG8 LF BK00564 Nylon 66
Ultramid Structure B3WG10 LF BK00564 Nylon 6
Ultramid Structure B3WG8 LF BK00564 Nylon 6
Ultramid T 4381 LDS Nylon 6/6T
Ultramid T KR 4350 Nylon 6/6T
Ultramid T KR 4355 G10 Nylon 6/6T
Ultramid T KR 4355 G5 Nylon 6/6T
Ultramid T KR 4355 G7 Nylon 6/6T
Ultramid T KR 4357 G6 Nylon 6/6T
Ultramid T KR 4365 G5 Nylon 6/6T
Ultramid TG3S Nylon 6
Ultramid TG3S BK-104 Nylon 6
Ultramid TG7S Nylon 6
Ultramid TG7S BK-102 Nylon 6
Ultramid TOP 3000 Nylon 6/6T